column 7 of the hazardous materials table

In addition, a lighter design intended to contain a non-pressurized Class 3 material is excepted from the examination and testing criteria specified in 173.308(b)(3). Except for transportation by aircraft, as an inner packaging of a combination packaging with a maximum net mass of 40 kg (88 pounds). Regulation Y TP25 Sulphur trioxide 99.95% pure and above may be transported in tanks without an inhibitor provided that it is maintained at a temperature equal to or above 32.5 C (90.5 F). When a special provision specifies packaging or packaging requirements - They will appear as a list of codes that are defined in 172.102 of the Code of Federal Regulations. (6) R codes. If the air bag inflator unit satisfactorily passes the series 6(c) test, it is not necessary to repeat the test on the air bag module. 39 This substance may be carried under provisions other than those of Class 1 only if it is so packed that the percentage of water will not fall below that stated at any time during transport. For vessel transport, the palletized loads, pallet boxes or unit load devices must be firmly packed and secured in closed cargo transport units; or. b. Each tank must be equipped with pressure relief devices conforming to the following requirements: 1 Total venting capacity in standard cubic feet hour (S.C.F.H.) As a 149 When transported as a limited quantity or a consumer commodity, the maximum net capacity specified in 173.150(b)(2) of this subchapter for inner packagings may be increased to 5 L (1.3 gallons). 49 CFR 172.101 46 This material must be packed in accordance with packing method OP6 (see 173.225 of this subchapter). 125 Lactose or glucose or similar materials may be used as a phlegmatizer provided that the substance contains not less than 90%, by mass, of phlegmatizer. Learn more about the eCFR, its status, and the editorial process. TP3 The maximum degree of filling (in %) for solids transported above their melting points and for elevated temperature liquids shall be determined by the following: Where: df and dr are the mean densities of the liquid at the mean temperature of the liquid during filling and the maximum mean bulk temperature during transport respectively. c. The cylinders are collected and transported by a private or a contract carrier for reconditioning, reuse or disposal. The material must be loaded dry. B83 Bottom outlets are prohibited on tank car tanks transporting sulfuric acid in concentrations over 65.25 percent. B81 Venting and pressure relief devices for tank car tanks and cargo tanks must be approved by the Associate Administrator. Uranium hexafluoride may be classified under this entry only if the conditions of 173.420(a)(4) and (6) and (d) and 173.421(b) and (d) of this subchapter, and, for fissile-excepted material, the conditions of 173.453 of this subchapter are met. 141 A toxin obtained from a plant, animal, or bacterial source containing an infectious substance, or a toxin contained in an infectious substance, must be classed as Division 6.2, described as an infectious substance, and assigned to UN 2814 or UN 2900, as appropriate. If appropriate, a package containing this material must conform to the additional labeling requirements of 172.402 of this subchapter. IBCs of type 31A and 31N are only authorized if approved by the Associate Administrator. This content is from the eCFR and is authoritative but unofficial. 105 The word Agents may be used instead of Explosives when approved by the Associate Administrator. In addition, the portable tank must be designed so that internal surfaces may be effectively cleaned and passivated. The receptacles must be constructed with glass double walls having the space between the walls vacuum insulated and each receptacle must be transported in an outer packaging with sufficient cushioning and absorbent materials to protect the receptacle from damage. Each radiation detector must meet the following conditions: (1) The pressure in each neutron radiation detector must not exceed 105 kPa absolute at 20 C (68 F); (2) The amount of gas must not exceed 13 grams (0.45 ounces) per detector; and, (3) Each neutron radiation detector must be of welded metal construction with brazed metal to ceramic feed through assemblies. B23 Tanks must be made of steel that is rubber lined or unlined. These special provisions are in addition to the standard packaging requirements. B68 Sodium must be in a molten condition when loaded and allowed to solidify before shipment. Symbols, if used, must be registered with the Associate Administrator. A210 This substance is forbidden for transport by air. A separate drafting site R1 A person who offers for transportation tank cars containing sulfur, molten or residue of sulfur, molten may reference the Sulfur Institute's, Molten Sulphur Rail Tank Car Guidance document (see 171.7 of this subchapter) to identify tank cars that may pose a risk in transportation due to the accumulation of formed, solid sulfur on the outside of the tank. Microsoft Edge, Google Chrome, Mozilla Firefox, or Safari. B27 Tanks must have a service pressure of 1,034 kPa (150 psig). Dry batteries not specifically covered by another entry in the 172.101 Table are covered by this entry (i.e., Batteries, dry, sealed, n.o.s.) In making this determination factors to be taken into consideration include, but are not limited to, the capacity and geometry of the packaging and the effect of any insulation present, the temperature of the material when offered for transport, the duration of the journey, and the ambient temperature conditions typically encountered in the journey (considering also the season of year), the effectiveness and other properties of the stabilizer employed, applicable operational controls imposed by regulation (e.g., requirements to protect from sources of heat, including other cargo carried at a temperature above ambient) and any other relevant factors. (3) Damage to terminals. 54 Maneb or maneb preparations not meeting the definition of Division 4.3 or any other hazard class are not subject to the requirements of this subchapter when transported by motor vehicle, rail car, or aircraft. Note that batteries utilizing different chemistries (i.e., those battery chemistries specifically covered by another entry in the 172.101 Table) as well as dry batteries with a marked rating greater than 9-volt may not be combined with used or spent batteries in the same package. TP9 A hazardous material assigned to special provision TP9 in Column (7) of the 172.101 Table may only be transported in a portable tank if approved by the Associate Administrator. B66 Each tank must be equipped with gas tight valve protection caps. 168 For lighters containing a Division 2.1 gas (see 171.8 of this subchapter), representative samples of each new lighter design must be examined and successfully tested as specified in 173.308(b)(3). TP12 This material is considered highly corrosive to steel. c. The equipment, and machinery or apparatus articles conforms with 173.222 of this subchapter. This entry does not apply to life saving appliances described in 173.219 (UN2990 and UN3072). 4 This material is poisonous by inhalation (see 171.8 of this subchapter) in Hazard Zone D (see 173.116(a) of this subchapter), and must be described as an inhalation hazard under the provisions of this subchapter. 370 This entry also applies to ammonium nitrate with not more than 0.2% combustible substances, including any organic substance calculated as carbon, to the exclusion of any added substance, that gives a positive result when tested in accordance with Test Series 2 of the UN Manual of Tests and Criteria, Part I (IBR; see 171.7 of this subchapter). (v) The box must be constructed from high-density polyethylene in the density range 0.950-0.962, and be capable of holding liquid when in the upright position. Outage must be sufficient to prevent tanks from becoming liquid full at 55 C (130 F). These provisions are multi-modal and apply to bulk and non-bulk packagings: 1 This material is poisonous by inhalation (see 171.8 of this subchapter) in Hazard Zone A (see 173.116(a) or 173.133(a) of this subchapter), and must be described as an inhalation hazard under the provisions of this subchapter. Other inorganic nitrate salts may replace part of the ammonium nitrate. Packaging Authorizations (Column 8) 65 The group of alkaline earth metals includes magnesium, calcium, strontium, and barium. An unused lighter or a lighter that is cleaned of residue and purged of vapors is not subject to the requirements of this subchapter. The outside of each package must be plainly marked ARTICLES, EXPLOSIVES, N.O.S. 169 This entry applies to lighter refills (see 171.8 of this subchapter) that contain a Division 2.1 (flammable) gas but do not contain an ignition device. 137 Cotton, dry; flax, dry; sisal, dry; and tampico fiber, dry are not subject to the requirements of this subchapter when they are baled in accordance with ISO 8115, Cotton Bales - Dimensions and Density (IBR, see 171.7 of this subchapter) to a density of not less than 360 kg/m3 (22.1 lb/ft3) for cotton, 400 kg/m3 (24.97 lb/ft3) for flax, 620 kg/m3 (38.71 lb/ft3) for sisal and 360 kg/m3 (22.1 lb/ft3) for tampico fiber and transported in a freight container or closed transport vehicle. Metal: 11A, 11B, 11N, 21A, 21B and 21N, b. 129 These materials may not be classified and transported unless authorized by the Associate Administrator on the basis of results from Series 2 Test and a Series 6(c) Test from the UN Manual of Tests and Criteria (IBR, see 171.7 of this subchapter) on packages as prepared for transport. Openings for safety relief devices on multi-unit tank car tanks shall be plugged or blank flanged. Multiple provisions can be listed in this column. The pressure relief device must be preceded by a frangible disk in accordance with the requirements in 178.275(g)(3) of this subchapter to prevent crystallization of the product in the pressure relief device. (iii) A copy of the test results must be kept on file at each facility where packagings are offered for transportation, and must be made available to a representative of the Department upon request. When phlegmatized with water and inorganic inert material, the content of urea nitrate must not exceed 75 percent by mass and the mixture should not be capable of being detonated by test 1(a)(i) or test 1(a)(ii) in the UN Manual of Tests and Criteria (IBR, see 171.7 of this subchapter). Testing must be conducted on at least three packages as prepared for transport. The articles may be transported as in Division 1.4 Compatibility Group D (1.4D) if all of the conditions specified in 173.63(a) of this subchapter are met. These provisions apply only to non-bulk packagings: N3 Glass inner packagings are permitted in combination or composite packagings only if the hazardous material is free from hydrofluoric acid. A portable tank may be offered for transport after the date of expiry of the last lining inspection for a period not to exceed three months for purposes of performing the next required test or inspection, after emptying but before cleaning. b. B130 When transported by motor vehicle, used diatomaceous earth filter material is not subject to any other requirements of this subchapter except for the shipping paper requirements of subpart C of part 172 of this subchapter; emergency response information as required by 172.602(a)(2) through (a)(7) of this subchapter; and the marking requirements of 172.302 of this subchapter, if the following requirements are met: a. Packagings are non-DOT specification sift-proof motor vehicles or sift-proof roll-on/roll-off bulk bins, which are covered by a tarpaulin or other equivalent means. Specification 110A500W tanks must be stainless steel. TP33 The portable tank instruction assigned for this substance applies for granular and powdered solids and for solids which are filled and discharged at temperatures above their melting point which are cooled and transported as a solid mass. A212 UN 2031, Nitric acid, other than red fuming, with more than 20% and less than 65% nitric acid intended for use in sterilization devices only, may be transported on passenger aircraft irrespective of the indication of forbidden in columns (9A) of the 172.101 table provided that: a. These provisions apply only to transportation by rail. (You can unsubscribe anytime), Learn More About USDOT/HazMat Transportation, generalpackaging requirements of173.24, Frequently Asked Questions Regarding the Regulations of the Resource Conservation and Recovery Act. Note also that this exception does not apply to batteries that have been reconditioned for reuse.

Science Museum Wedding Cost, Equinox Pool Sf, Diggz Xenon Plus Debrid, How Do The Readers And Billy's Contrasting Points, Richard Cheese Controversy, Articles C